Effect of storage time on the antinutritional factors, stability and rheological behaviours of flaxseed fortified wheat flours

Main Article Content

S. Hussain
F.M. Anjum
M.S. Butt
M.S. Alamri
A.A. Mohamed

Keywords

cyanogenic glycosidee, flaxseed, mixing time, peak height percentage, peroxide value, storage

Abstract



Whole wheat flour (WWF) and straight grade flour (SGF) were fortified with partially defatted flaxseed flour (PDF) and full fat flaxseed flour (FFF). The fortified flours were stored for a period of 60 days. Studies were conducted to evaluate the influence of storage intervals on stability, cyanogenic glycoside (HCN) content and rheological properties at 0, 30 and 60 days of storage. No HCN was detected in WWF samples while, its maximum concentration 0.37 and 0.44 mg/kg was found in 20% PDF and FFF fortified WWF, respectively. The storage intervals showed non-significant effect on the concentration of HCN among different composite flours. The peroxide value ranged from 0.82 to 0.92 mEq/kg in PDF fortified SGF composite flours, while it varied from 0.82 to 1.01 mEq/kg in FFF fortified SGF composite flours. The mixing time decreased significantly as the level of PDF and FFF fortification increased in SGF. Lower mixing times were recorded in both types of composite flours after 60 days of storage interval while fresh samples exhibited the higher mixing times. Significant changes in peak height percentages of both types of flours were observed during storage period of 60 days.




 
Abstract 101 | PDF Downloads 69

References

Addis, P.B and Warner, G.J., 1991. The potential aspects of lipid oxidation products in food. In:Auroma, O.I. and Halliwal, B. (eds.) Free radicals and food additives. Taylor and Francis, London, UK.
Afzal, B., 2004. Effect of different improvers on the functional properties of different wheat cultivars. MSc thesis, National InstituteofFood Science and Technology, UniversityofAgriculture, Faisalabad, Pakistan.
American Association of Cereal Chemists (AACC), 2000. Approved methods of the AACC. AACC, St. Paul, MN, USA.
Association of Official Analytical Chemists (AOAC), 1990. Officials methods of analysis of AOAC International (15th Ed.). AOAC, Gaithersburg, MD, USA.
Baixuli, R., Sanz, T., Salvador, A. and Fiszman, S.M., 2007. Influence of the dosing process on the rheological and microstructural properties of a bakery product. Food Hydrocolloids 21: 230-236.
Barlow, S.N., 1990. Toxicological aspects of antioxidants used as food additives. In: Hudson, B.J.F. (ed.) Food antioxidants. Elsevier, Amsterdam, the Netherlands, pp. 253-307.
Blokshma, A.H. and Bushuk, W., 1988. Rheology and chemistry of dough. In: Pomarenz, Y. (ed.) Wheat chemistry and technology, volume 2. AACCI, St. Paul, MN, USA.
Butt, M.S., Anjum, F.M., Ali, A. and Rehman, A., 1997. Milling and baking properties of spring wheat. Journal of Agricultural Research 35: 403-412.
Chen, Z., Schols, H.A. and Voragen, A.G.J., 2003. The use of potato and sweet potato starches affects white salted noodle quality. Journal of Food Science 68: 2630-2637.
Daun, J.K., 2001. Storage stability of milled flaxseed. Journal of American Oil Chemists Society38: 105-106.
Dessi, M.A., Deiana, M., Dat, B.W., Rosa A., Banni, S. and Corongiu, F.P., 2002. Oxidative stability of polyunsaturated fatty acids: effect of squalene. European Journal of Lipid Science and Technology 104: 506-512.
Dhingra, S. and Jood, S., 2004. Effect of flour blending on functional, baking and organoleptic characteristics of bread. International Journal of Food Science and Technolology 39: 213-222.
Feng, D., Shen, Y. and Chavez, E.R., 2003. Effectiveness of different processing methods in reducing hydrogen cyanide content of flaxseed. Journal of Science of Food Agriculture 83: 836-841.
Finney, K.F., 1984. An optimized straight-dough, bread making method after 44 years. Cereal Chemistry 621: 20-27.
Fitzpatrick, K., 2006. Plant based omega-3: chemistry, applications and potential health benefits. 97th AOCS Annual Meeting and Expo, April 30-May 3, 2006, America’s Center, St. Louis, MO, USA.
Garden, J.A., 1993. Flaxseed gum: extraction, characterization and functionality. PhD thesis, North Dakota State University, Fargo, ND, USA.
Gujral, H.S. and Singh, N., 1999. Effect of additives on dough development gaseous release and bread making properties. Food Research International 32: 691-697.
Hallen. E., IIbanoglu, S. and Ainsworth, P., 2004. Effect of fermented/germinated cowpea flour addition on the rheological and baking properties of wheat flour. Journal of Food Engineering 63: 177-184.
Hurrell, R.F., 1997. Preventing iron deficiency through food fortification. Nutrition Review55: 210-222.
Hussain, S., Anjum, F.M., Alamri, M.S., Mohammed, A.A. and Nadeem, M., 2013. Functional flaxseed in baking. Quality Assurance and Safety of Crops and Foods 5: 375-385.
Hussain, S., Anjum, F.M., Butt, M.S., Alamri, M.S. and Khan, M.R., 2012. Biochemical and nutritional evaluation of unleavened flat breads fortified with healthy flaxseed. International Journal of Agriculture and Biology 14: 190-196.
Hussain, S., Anjum, F.M., Butt, M.S., and Sheikh, M. A., 2008. Chemical compositions and functional properties of flaxseed flour. Sarhad Journal of Agriculture 24: 649-653.
Hussain, S., Anjum, F.M., Butt, M.S., Khan, M.I. and Asghar, A., 2006. Physical and sensoric attributes of flaxseed flour supplemented cookies. Turkish Journal of Biology 30: 87-92.
Kent, N.L. and Evers, A.D., 1994. Technology of cereals (4th Ed.). Pergamon Press, Oxford, UK.
Kirk, S.R. and Sawyer, R., 1991. Pearson’s composition and analysis of foods (9th Ed.). Addison Wesley Longman Ltd, Harlow, UK.
Koca, A.F. and Anil, M., 2007. Effect of flaxseed and wheat flour blends on dough rheology and bread quality. Journal of Science of Food and Agriculture 87: 1172-1175.
Leelavathi, K. and Haridas Rao, P., 1988. Chapati from germinated flour. Journal of Food Science and Technology 25: 162-164.
Martin, J.R., 2004. Flaxseed summary of storage and cooking stability studies. Available at: http://www.flaxrd.com/.
Oomah, B.D. and Mazza, G., 1997. Effect of dehulling on chemical composition and physical properties of flaxseed. LWT – Food Science and Technology 30: 135-140.
Oomah, B.D. and Mazza, G., 1998. Flaxseed products for disease prevention. In: Mazza, G. (ed.) Functional foods: biochemical and processing aspects. Technomic Publishing, Lancaster, PA, USA, pp. 91-138.
Rasool, G., 2004. Characterization and evaluation of wheat flour enriched with oilseed proteins for chapatti making. PhD thesis, National InstituteofFood Science and Technology, UniversityofAgriculture, Faisalabad, Pakistan.
Ratnayake, W.M.N., Behrens, W.A., Fischer, P.W.F., L’Abbe, M.R., Mongeau, R. and Beare-Rogers, J.L., 1992. Flaxseed: chemical stability and nutritional properties. Journal of Nutrition and Biochemistry 3: 232-240.
Seguchi, M., Tabara, A., Fukawa, I., Ono, H., Kumashiro, C., Yoshino, Y., Kusunose, C. and Yamane, C., 2007. Effects of size of cellulose granules on dough rheology, microscopy, and bread making properties. Journal of Food Science 72: E79-E84.
Singh. N., Bajaj, I.K., Singh, R.P. and Gujral, H.S., 2002. Effect of different additives on mixograph and bread making properties of Indian wheat flour. Journal of Food Engineering 56: 89-95.
Steel, R.G.D., Torrie, J.H. and Dickey, D.A., 1997. Principles and procedures of statistics; a biometrical approach (3rd Ed.). McGraw Hill Book Co. Inc., New York, NY, USA.
Yang, H., Mao, Z. and Tan, H., 2004. Determination and removal methods for cyanogenic glycoside in flaxseed. American Society of Agricultural and Biological Engineers, St. Joseph, MI, USA.